|
| shazza9275 |
|
||
|
how easy it it to swap over a fuel pump mine is on the way out??
|
||
| Top | |
||
| XRfairmont67 |
|
|||
|
http://cgi.ebay.com.au/GENUINE-FORD-EA- ... 563a3c2dc6
they are not too hard to replace remove the 6 screws from the cover plate on the boot floor (under carpet, lh side) remove large hose clamp that holds the retaining ring on. remove wiring plugs and fuel lines (push plastic ring towards pump and gently pull the hose out of the sender) the retainer ring can sometimes be awkward, tight too. i have removed the ring on a couple of cars using a large flathead screwdriver and hammer, just tap it around anticlockwise there is a tool shown in the gregorys manuals etc that u can make and this makes it easier. once retainer is removed carefully lift pump out of tank, watching not to bend the sender unit arm. the pump has a tab and usually a zip tie holding it to the sender, bend the tab back slightly on the top end, theres a rubber coupling which can be pushed back and the pump should pivot out |
|||
| Top | |
|||
| shazza9275 |
|
||
|
im not 100% sure if it is the pump is there any way to check?
|
||
| Top | |
||
| SV-Valiant |
|
||
|
if you pull the pump out you can check it on your battery just add a couple of wires to the two plugs then hold them onto the battery if its works its good if nothing its dead the clip that looks like a radiator clip on the big black thing that unsrews is a b**ch to get off i normally use a screw driver and force it off it it doesent remove easy then throw it away it doesent need it when put it all back together.. Also before connecting to your battery just make sure you dont have petrol dripping out of it.
I also once made a tool to remove the black cover but found it useless so just used a big set of multi grips to twist it off. if you need another pump you can find them in the for sale section for around 10 - 15 dollars cheers Alan |
||
| Top | |
||
| shazza9275 |
|
||
|
thanks guys and it was fairly easy get the pump out i bought a new bosch fuel pump which was apparently for a car like mine but i put it in and it would pump but it wasnt getting enough fuel to the engine but i put the old pump back in and it would start and run fine any ideas?
|
||
| Top | |
||
| ghia97 |
|
||
|
Injectors, Fuel pressure regulator.
|
||
| Top | |
||
| GASSA |
|
||
|
Mate
Have u changed the inline fuel filter just forward of rear lh wheel under lh rear door gassa
_________________ When the clutch drops the bull s**t stops!!!!! |
||
| Top | |
||
| shazza9275 |
|
||
|
i dont understand how the old pump works and the car starts and everything but with the new pump it doesnt wanna start ?
|
||
| Top | |
||
| TROYMAN |
|
||
|
{USERNAME} wrote: i dont understand how the old pump works and the car starts and everything but with the new pump it doesnt wanna start ? sounds like the pump is either the wrong pump or its faulty.. |
||
| Top | |
||
| shazza9275 |
|
||
|
is there any way to test if the new pump is running ok ?
there is a brown box inside my fuel tank anyone know what its for ? apparently there is a specific way the filter is supposed to go on in the tank can anyone confirm this ? |
||
| Top | |
||
| GASSA |
|
||
|
[quote="shazza9275"]is there any way to test if the new pump is running ok ?
there is a brown box inside my fuel tank anyone know what its for ? apparently there is a specific way the filter is supposed to go on in the tank can anyone confirm this Mate if you put the wire on the wrong way the pump will not pump fuel try changing the wires around. Remove the supply hose connector get someone to turn the ignition on you should hear the pump working and petrol will flow if the pump is working and no fuel change the wires around also check the pickup filter on the end of the pump. If you didnot change it it could be blocked If there is no noise it could be a faulty relay under the water recovery bottle. gassa
_________________ When the clutch drops the bull s**t stops!!!!! |
||
| Top | |
||
| shazza9275 |
|
||
|
all good i got the pump working cheers guys
|
||
| Top | |
||
| ghia97 |
|
||
|
What was it?
|
||
| Top | |
||
| shazza9275 |
|
||
|
have to put the filter a certain way and just tweeked the wires a little but not much different from before but it works so all good
|
||
| Top | |
||
| Who is online |
|---|
Users browsing this forum: No registered users and 21 guests |
