|
| young falcon |
|
||
Age: 28 Posts: 25 Joined: 24th Jan 2015 Ride: 1994 Falcon futura Wagon Location: Elizabeth East |
hi all I have run into a problem with my EF when I brought it the oil looked a bit old and so decided to give it a change with a new filter and Gulf Western 20-50 SJ CF coded oil and now after about an hours worth of driving my oil light comes on but the motor doesn't sound like its being starved of oil it usually hangs around the MAL range on the temp gauge and the light flickers when this problem happens at idle and sometimes stays on, which is a bit worrying any assistance is appreciated
|
||
| Top | |
||
| TimmyA |
|
|||
|
I thought EF/EL were a 15/40 oil recommended...
None the less this was common issue with these models... AFAIK Ford issued a fix to technicians for this and it was to add a resistor inline with the sensor to lift the needle on the gauge... If you screw a master gauge (mechanical) straight into the sender hole you'd find you probably have good oil pressure and it's the factory gauge that is lying... If you have a spare pressure gauge handy it'd be worth a try... My ED did this to me only a couple of times in it's life... Cheers, Tim
_________________ 93 Red ED 5spd Manual Build Thread |
|||
| Top | |
|||
| SWC |
|
||
|
young falcon wrote: hi all I have run into a problem with my EF when I brought it the oil looked a bit old and so decided to give it a change with a new filter and Gulf Western 20-50 SJ CF coded oil and now after about an hours worth of driving my oil light comes on but the motor doesn't sound like its being starved of oil it usually hangs around the MAL range on the temp gauge and the light flickers when this problem happens at idle and sometimes stays on, which is a bit worrying any assistance is appreciated Please Clarify a couple of things, 1) What dash is it? Low series (GLi/Futura) or High (XR/Fairmont). 2) You talk of low oil pressure but refer to the temp gauge. Are you say the car is running normal temp when the oil pressure drops. 3) The oil light doesn't come on when the car/oil is cold? or only when Hot? |
||
| Top | |
||
| young falcon |
|
||
Age: 28 Posts: 25 Joined: 24th Jan 2015 Ride: 1994 Falcon futura Wagon Location: Elizabeth East |
SWC wrote: young falcon wrote: hi all I have run into a problem with my EF when I brought it the oil looked a bit old and so decided to give it a change with a new filter and Gulf Western 20-50 SJ CF coded oil and now after about an hours worth of driving my oil light comes on but the motor doesn't sound like its being starved of oil it usually hangs around the MAL range on the temp gauge and the light flickers when this problem happens at idle and sometimes stays on, which is a bit worrying any assistance is appreciated Please Clarify a couple of things, 1) What dash is it? Low series (GLi/Futura) or High (XR/Fairmont). 2) You talk of low oil pressure but refer to the temp gauge. Are you say the car is running normal temp when the oil pressure drops. 3) The oil light doesn't come on when the car/oil is cold? or only when Hot? Apologies for not making much sense but it is the low series dash, it is normal operating temperature when the problem happens and only happens when hot, like if I travel around an hour or so then it starts flickering and after about another 5-10 minutes it wil Will be bright |
||
| Top | |
||
| SWC |
|
||
|
So, when it hits "Low" Oil Pressure, the light flickers and then stays on?
Does this occur at revs or only at idle? If you turn the car off and then restart it straight away, does the light still come on and stay on or does it "reset"? |
||
| Top | |
||
| young falcon |
|
||
Age: 28 Posts: 25 Joined: 24th Jan 2015 Ride: 1994 Falcon futura Wagon Location: Elizabeth East |
SWC wrote: So, when it hits "Low" Oil Pressure, the light flickers and then stays on? Does this occur at revs or only at idle? If you turn the car off and then restart it straight away, does the light still come on and stay on or does it "reset"? Yes it does flicker then stays on, it occurs at idle and the revved, it comes up straight away most times but does occasionally does reset itself |
||
| Top | |
||
| SWC |
|
||
|
Either you have a stuffed oil pressure switch (Hope) which is a easy fix or you have bigger problems.
Supercheap do the switches, Triton $11.99 or VDO $14.99. It would pay to put a mechanical gauge on the engine to check the oil pressure. The oil shouldn't cause an issue. What oil filter did you use? On the bigger issue side, Oil pump could be on the way out, relief valve sticking open or vanes worn or possibly bottom end is on the way out. How many Km on the engine? |
||
| Top | |
||
| young falcon |
|
||
Age: 28 Posts: 25 Joined: 24th Jan 2015 Ride: 1994 Falcon futura Wagon Location: Elizabeth East |
SWC wrote: Either but have a stuffed oil pressure switch (Hope) which is a easy fix or you have bigger problems. Supercheap do the switches, Triton $11.99 or VDO $14.99. It would pay to put a mechanical gauge on the engine to check the oil pressure. The oil shouldn't cause an issue. What oil filter did you use? On the bigger issue side, Oil pump could be on the way out, relief valve sticking open or vanes worn or possibly bottom end is on the way out. How many Km on the engine? As far as I know it has done 382,500 thereabouts but I think it was a bandaid job by previous owner, it's got a number corresponding to a EL sedan but has all the EDIS gear, I am using ryco filters |
||
| Top | |
||
| SWC |
|
||
|
Filter is good.
Check the switch and see how you go. I hope that is the fix for you. |
||
| Top | |
||
| young falcon |
|
||
Age: 28 Posts: 25 Joined: 24th Jan 2015 Ride: 1994 Falcon futura Wagon Location: Elizabeth East |
SWC wrote: Filter is good. Check the switch and see how you go. I hope that is the fix for you. Sure, I will let everyone know how it goes |
||
| Top | |
||
| SWC |
|
||
|
Check to see if there is any oil leaking around the Oil Switch.
On the Oil Gauge Sensor units, they can start leaking and start giving false readings. I would still put a proper pressure gauge on it and have it checked. |
||
| Top | |
||
| Who is online |
|---|
Users browsing this forum: No registered users and 56 guests |
