|
| brettv |
|
||
|
hi my el wagon has a fault with the abs the light comes on most of the time ive checked the code and checked the wiring voltages and replaced the unit my old unit then worked on another car. has any one had any problems with wiring faults ????
|
||
| Top | |
||
| Krytox |
|
|||
|
Did you replace the pump?
Im trying to figure out how much you know about the modules.
_________________ Carefree, we may not be number one, but we're up there. |
|||
| Top | |
|||
| brettv |
|
||
|
yes the module was replaced (pump with intergral computer) and when fitted to another vehicle it then worked fine. after replacing the pump i reset the codes too. but the problem was the same as before
|
||
| Top | |
||
| svo_matt |
|
|||
|
I had this problem yesterday, check all the sensors (i found my left front was melted near the extractor) and the wiring also where it plugs in the the pump
_________________ ..My fake plant died because I forgot to pretend to water it.. |
|||
| Top | |
|||
| brettv |
|
||
|
svo_matt wrote: I had this problem yesterday, check all the sensors (i found my left front was melted near the extractor) and the wiring also where it plugs in the the pump
the spot where it melted thru probably caused the problem at the connector, on mine every thing looks fine visually havent found any melted wires or any thing |
||
| Top | |
||
| snap0964 |
|
|||
|
So what codes came up ??
_________________ 96 XH Longreach 'S': LPG, Alarm, 3.23:1 LSD, Cruise, Trip Comp, ABS, Power Windows, Mid Series Dome Lt, Climate Ctrl |
|||
| Top | |
|||
| brettv |
|
||
|
snap0964 wrote: So what codes came up ??
it was code 63 i think |
||
| Top | |
||
| snap0964 |
|
|||
|
from http://www.fordmods.com/forums/documents.php?doc=2 :
Valve Relay, or Valve Relay supply voltage fault The EL's run the later Bosch 503 unit (the one pictured in the doco is an early EF one). Plug your old unit back in - it doesn't need to be hooked up to the brake lines for testing purposes. I'm suspecting there is a bad connection between the ABS pins and the plug sockets - the unit may be faulty, but they were pretty reliable units.
_________________ 96 XH Longreach 'S': LPG, Alarm, 3.23:1 LSD, Cruise, Trip Comp, ABS, Power Windows, Mid Series Dome Lt, Climate Ctrl |
|||
| Top | |
|||
| brettv |
|
||
|
the unit should be ok it was working when i took it out of the other vehicle, the voltages pin point tested ok when i did the change over but the abs light was off then it comes and goes thats why i suspected a wiring fault and was wondering if any one had any similar wiring problems?
|
||
| Top | |
||
| rdiigen |
|
|||
|
Where is the valve relay... i've got code 63 but cant find it in gregorys.
|
|||
| Top | |
|||
| brettv |
|
||
|
on the el its all part of the unit under the front l/h guard
|
||
| Top | |
||
| Who is online |
|---|
Users browsing this forum: No registered users and 81 guests |
