|
| millard455 |
|
|||
|
hi everyone
well i thaught my fuel pump died but before replacing it i thaught id better check for power at the pump incase it is just a dead relay and i can only get 1 source of power at the fuel pump out of the 4 wires. should i be getting 2 live wires, one to power the pump and one to power the gauge sender unit?? thanks heaps
_________________ EL XR8 SERIES 2, 5SPD, HOT CHILLI RED, 200 ODD RWKW OF V8 FUN AND GAMES |
|||
| Top | |
|||
| horses4courses |
|
|||
|
should be constant power to fuel level sender with key on.
Power will only go to the pump for about 3sec when ignition turend on without car running. You will need a mate to turn key for you or rig up a light to ckeck with. i've just had same happen to me i've got new pump on order hoping it wll fix problem. Mines an AUIIIXR6, fuel pump wire is black with yellow stripe. Hope this helps Chris
_________________ AUIIIXR6, Ultra low king springs, monro shocks, 19" of Chrome XHP Jets ,Snort Stage 4 turbo mainafold, GT 42r turbo, 3" stainless cooler piping, Haltech E6X, 42lb injectors,10mm Topgun leads,rising fuel reg, Bosch 040 fuel pump15psi = 283rwkw 802nm of tyre shreding touqe and a 12.6@118mph. |
|||
| Top | |
|||
| horses4courses |
|
|||
|
If no power u can swap relays under bonet to check them, I think most r the same just match up numbers. I havn't had much to do with E series but don't think much would have chaned between our modles.
Chris
_________________ AUIIIXR6, Ultra low king springs, monro shocks, 19" of Chrome XHP Jets ,Snort Stage 4 turbo mainafold, GT 42r turbo, 3" stainless cooler piping, Haltech E6X, 42lb injectors,10mm Topgun leads,rising fuel reg, Bosch 040 fuel pump15psi = 283rwkw 802nm of tyre shreding touqe and a 12.6@118mph. |
|||
| Top | |
|||
| millard455 |
|
|||
|
{USERNAME} wrote: should be constant power to fuel level sender with key on.
Power will only go to the pump for about 3sec when ignition turend on without car running. You will need a mate to turn key for you or rig up a light to ckeck with. i've just had same happen to me i've got new pump on order hoping it wll fix problem. Mines an AUIIIXR6, fuel pump wire is black with yellow stripe. Hope this helps Chris yeah mate, big help as i was looking for constant power and could only find 1 wire with power but that was after i turned the key then went and climbed in my boot. i will get my missus to turn the key while ive got the multimeter hooked up and see how that goes. thanks heaps mate.
_________________ EL XR8 SERIES 2, 5SPD, HOT CHILLI RED, 200 ODD RWKW OF V8 FUN AND GAMES |
|||
| Top | |
|||
| xr6eat 50 |
|
|||
|
Power wire for the pump is the bigger wire, black with the yellow band in my ef should be the same for the el
_________________ EF XR6 Manual 271RWHP/199RWKW N/A using Stock manifold with dual plane runners still operating. EFI Hardware 6TBM to come mid year. |
|||
| Top | |
|||
| horses4courses |
|
|||
|
Its a good idea to check earths to as wires do where through in some case's.
Chris Merry Christmas
_________________ AUIIIXR6, Ultra low king springs, monro shocks, 19" of Chrome XHP Jets ,Snort Stage 4 turbo mainafold, GT 42r turbo, 3" stainless cooler piping, Haltech E6X, 42lb injectors,10mm Topgun leads,rising fuel reg, Bosch 040 fuel pump15psi = 283rwkw 802nm of tyre shreding touqe and a 12.6@118mph. |
|||
| Top | |
|||
| snap0964 |
|
|||
|
As mentioned, the bigger wires are pump power, smaller will be the sender.
If you earth the top right pin of the diagnosis connector, and turn ignition on, the pump should run continuously. This also tests the function of the ECU relay and fuel pump relay and wiring.
_________________ 96 XH Longreach 'S': LPG, Alarm, 3.23:1 LSD, Cruise, Trip Comp, ABS, Power Windows, Mid Series Dome Lt, Climate Ctrl |
|||
| Top | |
|||
| horses4courses |
|
|||
|
True
 , in my au biggest wires are both earth's, don't rember what colour earths were though? fuel pump positve was black and yellow.
How did the test go. Chris
_________________ AUIIIXR6, Ultra low king springs, monro shocks, 19" of Chrome XHP Jets ,Snort Stage 4 turbo mainafold, GT 42r turbo, 3" stainless cooler piping, Haltech E6X, 42lb injectors,10mm Topgun leads,rising fuel reg, Bosch 040 fuel pump15psi = 283rwkw 802nm of tyre shreding touqe and a 12.6@118mph. |
|||
| Top | |
|||
| millard455 |
|
|||
|
hi all
had my multimeter hooked up to the pump power wire and got the missus to hit the key and had power for a few seconds so it must be a dead fuel pump, thaught it was but thaught id better make sure. thanks heaps for all the help guys 
_________________ EL XR8 SERIES 2, 5SPD, HOT CHILLI RED, 200 ODD RWKW OF V8 FUN AND GAMES |
|||
| Top | |
|||
| 98el16 |
|
||
|
i think i may have run in to a similar problem, does the pump run fuel up constantly when the key is on accessory or is it for only a couple seconds?
|
||
| Top | |
||
| 98el16 |
|
||
|
right i found the problem after 2 days and overhouling the fuel system i found it, in the ef if the interior light isnt on the car wont start, and of course the fuse for the interior light was blown and i put a new fuse in and shes rokin n rollin, so mate if thats the same 4 u check mate. cheers hope it helps.
|
||
| Top | |
||
| Who is online |
|---|
Users browsing this forum: No registered users and 28 guests |
